Inovasi IoT: Alat dehidrasi bioetanol dari limbah bonggol jagung untuk energi terbarukan

Destica  Pitrianti; Rara Weinita  Naiya; Miftah Azzura  Ramadavini

doi:10.70310/az4epw08

Inovasi IoT: Alat dehidrasi bioetanol dari limbah bonggol jagung untuk energi terbarukan

Authors

Destica Pitrianti ¹ , Rara Weinita Naiya ² & Miftah Azzura Ramadavini ³

1 Teknik Komputer, Politeknik Negeri Sriwijaya

2 Teknik Komputer, Politeknik Negeri Sriwijaya

3 Teknik Komputer, Politeknik Negeri Sriwijaya

Published online: 13 Dec 2024

10.70310/az4epw08

Abstract

Mardiharjo Village, Musi Rawas Regency, is facing the issue of corn cob waste that is not being utilized optimally and is polluting the environment. Corn cobs contain cellulose and hemicellulose, which have the potential to be processed into bioethanol. This research aims to design an IoT-based bioethanol dehydration device that can purify bioethanol to a concentration of 99%, in accordance with fuel standards. This device is equipped with a dehydration column, heater, condenser, and automatic control using a microcontroller. IoT technology enables real-time temperature monitoring for energy efficiency. The design was created using Tinker software and thoroughly documented. This innovation is expected to open up opportunities for utilizing corn waste as renewable energy and an environmental solution in the agricultural sector.

Keywords:

Bioethanol Production Corn Cob Waste Bioethanol Dehydration IoT Technology

References

Amrika. (2020). Analisis Produktivitas Jagung di Provinsi Sumatera Selatan 2020. https://sumsel.bps.go.id/id/publication/2021/12/31/91ffa3469df78525e29a6996/analisis-produktivitas-jagung-di-provinsi-sumatera-selatan-2020--hasil-survei-ubinan-.html

Azwardi, A., Saputra, A., Jumeilah, F. S., & Saputra, K. A. (2024). Prototype of Indoor Air Purification Device Based on IoT (pp. 419–425). https://doi.org/10.2991/978-94-6463-386-3_44

Chusna, F. M. A., Cahaya, S., & Aprianita, S. (2024). Optimasi Pembuatan Bioetanol dari Limbah Bonggol Jagung Berdasarkan Beda Waktu Fermentasi dan Berat Ragi.

Limantara, A. D., Purnomo, Y. C. S., & Mudjanarko, S. W. (2017). Pemodelan sistem pelacakan lot parkir kosong berbasis sensor ultrasonic dan internet of things (iot) pada lahan parkir diluar jalan.

Murtiningsih, T., & Johanda, A. (2023). Analisis kontribusi pendapatan usahatani jagung terhadap pendapatan keluarga di desa kutosari kecamatan belitang iii kabupaten oku timur. In JASEP (Vol. 9, Issue 2).

Novianto, & Wahyuni, S. T. (2023). Sosialisasi dan demonstrasi pemanfaatan limbah bonggol jagung dan tanaman lamtoro dalam pembuatan pupuk nabati.

Oktavia, Z., Hadi Darwanto, D., & Hartono, S. (2015). Sektor Pertanian Unggulan di Sumatera Selatan. AGRARIS: Journal of Agribusiness and Rural Development Research, 1(2), 61–69. https://doi.org/10.18196/agr.129

Susnadi, D. (2018). Teknologi pengolahan tongkol jagung (zea mays) menjadi bioetanol sebagai bioenergi alternatif.

Winarso, R., & Setya Nugraha, B. (2015). Rancang bangun alat dehydrator bioetanol untuk menghasilkan fuel grade ethanol (FGE). Jurnal SIMETRIS, 6.

Wirawan, I. P. S., Arnata, I. W., & Nada, I. M. (2014). Perancangan dan uji alat dehidrator penyaring molekul tipe tunggal untuk pemurnian bioetanol.

License

This work is licensed under a Creative Commons Attribution 4.0 International License.

Permission is granted subject to the terms of the License under which the work was published. Permission will be required if your reuse is not covered by the terms of the License.

How to Cite

[1]

D. . Pitrianti, R. W. . Naiya, and M. A. . Ramadavini, “Inovasi IoT: Alat dehidrasi bioetanol dari limbah bonggol jagung untuk energi terbarukan”, J Teknologi Cerdas, vol. 2, no. 1, Dec. 2024, doi: 10.70310/az4epw08.